Emission Warranty

(Applicable for vehicles sold from 01/07/2001 in Delhi-NCR, Mumbai, Kolkata and Chennai only).
Subject to other terms of the warranty policy and the conditions and obligation laid down hereunder, Hyundai Motor India Limited hereinafter called “HMIL”, certifies that the components liable to affect the emission of the gaseous pollutants in the vehicle in normal use despite the use to which it may be subjected, comply with the provisions of Rule 115(2) of the Central Motor Vehicle Rules, 1989 hereinafter referred to as the “In-use emission standard”, and further warrants that if on examination by a dealer duly authorized by HMIL, the vehicle is discovered to be failing to meet the In-use emission standard as specified in the said rule, our Authorized Dealer shall take such corrective measures as may be necessary and shall at its sole discretion either repair or replace free of charge, such components of emission control system as are specified below.

enlarge

Warranty period

Applicable for EON,ELITE i20, GRAND i10,XCENT & i20 ACTIVE (Sold 1st March 2018 onwards):
This warranty will be in addition to and run parallel to the New Vehicle Warranty and shall exist for a period of 36 months/80K Km whichever occurs first. This warranty is transferable to subsequent owner for the remaining warranty period as mentioned above.

Applicable for CRETA,VERNA & TUCSON:
This warranty will be in addition to and run parallel to the New Vehicle Warranty and shall exist for a period of 36 months from the date of delivery to the first purchaser, irrespective of the mileage. This warranty is transferable to subsequent owner for the remaining warranty period as mentioned above.

What is covered?

Our Authorized Dealers shall either repair or replace, any Hyundai genuine part listed under What is not Covered hereof, that is acknowledged by HMIL to be defective in material or workmanship within the warranty period stipulated above, after examinations carried out to confirm that none of the original settings have been tampered with, at no cost to the owner of the Hyundai vehicle for parts or labour. Such defective parts which have been replaced will become the property of HMIL.

Emission Warranty Part List

Engine Control Module System
Engine Control Module
Crankshaft Position Sensor, Camshaft Position Sensor, Throttle Position Sensor, MAP Sensor, O2 Sensor, IAT & ECT Sensor

Fuel Metering System
Fuel injectors
Fuel pumps

Air Induction System
Air Cleaner Housing Assembly
Throttle Body
Intake Manifold
Idle Speed Control Actuator

Ignition System
H.T. Cable Set
Ignition Coil
Power Transistor
Distributor and internal parts

Evaporative Emission Control System
Vapour Storage Canister
Fuel Tank
Fuel Filler Tube and Fuel filler Cap
Purge Control Solenoid Valve
Canister Close Valve

PCV System
PCV Hoses
PCV Valve
Oil Filler Cap

Catalytic Converter System
Exhaust Manifold
Exhaust Pipe Assembly
Catalytic Converter

Exhaust Gas Recirculation (EGR) System (Diesel Engines)
EGR Control System

Miscellaneous items used in above Systems
Vacuum hoses clamps, fittings, tubing or mounting hardware used with the above systems. Valves, Switches and Solenoids

What is not covered?

This Emission Warranty shall not apply to :

Normal maintenance services including without limitation, engine tuning, oil/fluid changes, filters replenishment, etc.

Replacement of parts as a result of normal wear and tear such as spark plugs, filters, etc.

The vehicle reported without valid Pollution under Control’ certificate for the period immediately preceding the test during which the failure is discovered.

The vehicle which has been run on adulterated fuel or lubricant or fuel/lubricants other than those specified by HMIL.

Damage or failure resulting from :

Negligence of proper maintenance as required in this Owner’s Manual and Service Booklet.

Misuse, abuse, accident, theft, flooding or fire.

Use of improper or insufficient fuel, fluids or lubricants.

Any repair carried out other than by Hyundai Authorized Dealer/ Service Centre.

Use of parts other than Hyundai Genuine Parts.

Any device and/or accessories not supplied by HMIL

Modifications, alterations, tampering or improper repair.

Parts used in applications for which they were not designed or not approved by HMIL.

Any penalties that may be charged by statutory authorities on account of failure to comply with the In-use emission standards.

The vehicle in which the odometer has been tampered with, changed or been disconnected.

Any consequential repairs or replacement of parts which may be found necessary to establish compliance to In-use emission standards, in addition to the replacement of the components covered under Emission Warranty, will not be made free of cost unless such parts are also found to be in warrantable condition within the scope and limit of the New Vehicle Warranty.

Incidental or consequential damages, including without limitation, loss of time, inconvenience, loss of use of vehicle or commercial loss.

This warranty will be in addition to and run parallel to the New Vehicle Warranty and shall exist for a period of 36 months from the date of delivery to the first purchase irrespective of mileage. This warranty is transferable to subsequent owner for the remaining warranty period.

Owner’s Responsibilities

Proper use, maintenance and care of vehicle in accordance with the instructions contained in this Owner’s Manual and Service Booklet. If the vehicle is subject to severe usage conditions, such as operation in extremely dusty, rough, more repeated short distance driving or heavy city traffic during hot weather, maintenance of vehicle should be done more frequently as mentioned in this Owner’s Manual and Service Booklet.

In order to maintain the validity of this Emission Warranty, the vehicle must be serviced by Hyundai Authorized Dealer or Service Centre in accordance to the Owner’s Manual and Service Booklet.

Retention of maintenance service records. It may be necessary for the customer to show that the required maintenance has been performed, as specified in this Owner’s Manual and Service Booklet.

Immediate Delivery of the vehicle to any authorized Hyundai Dealer upon discovery of failure to comply with the In-use emission standard in spite of proper use, maintenance and care of vehicle in accordance with the instructions contained in this Owner’s Manual and Service Booklet.

Production of “Pollution Under Control" (PUC) certificate valid for the period immediately preceding the test during which the failure is discovered, the test having been carried out either for obtaining a new certificate, or pursuant upon being directed by an officer as referred to in sub-rule (2) of Rule 116 of the Central Motor Vehicles Rules.